These hard drives, mostly DTLA and AVER families, became infamous for their reportedly high failure rates. IBM(later Hitachi) is widely known in data recovery business for their line of DeskStar HDDs also known as DeathStars. One of them is heads sticktion to the platter surface.I recently build a new computer and when I went to plug this hard drive - Hitachi - to retrieve all my data, the BIOS never recognized it and I never heard it spin up. Hitachi laptop drives(HTS models) share some typical 2.5 inch HDD problems. Before doing any clean room work, it is very important to perform accurate diagnostics and eliminate a chance of possible firmware corruption that sometimes can also cause clicking. Most often this a sign of bad heads and the drive needs head assembly swapped from a matching donor. The drive spins up and the head starts clicking from the start. In our lab we use specialized software and hardware to rebuild these adaptive parameters located in the NVRAM to make donor PCB fully compatible with failed drive.Īnother quite common symptom Hitachi drives experience is clicking or knocking sound. The problem is that logic board on modern hard drive is adapted to the head disk assembly it was manufactured with. Moreover, donor board could "lock" itself causing a good working donor drive not to spin. If this is the case you can try to swap PCB from another drive of the same model but the chances are close to zero. Hot plugging in to a different computer via a USB external enclosure, Windows would begin the new hardware install but then "fail to recognize the device". Problem was discovered when shortcut to this drive failed to find it and PC will not boot with this drive connected, there were no odd noises, system crash or error messages at all. My Hitachi HTS548040M9AT00 is the 2nd drive on my XP machine used only for storing photos (no OS). Any further attempts to read from these areas would shorten the drive's life and may result in further unrecoverable data loss. It's critical at this point to stop reading from such drive and bring it for diagnostics to the professional data recovery lab. Capable But Command Failed" or some other hard drive error on boot. If you attempt to boot up from such drive or read any data from it you would get "Primary Master Hard Disk Fail", "No operating system found", "USB Device malfunctioned" error, "S.M.A.R.T. If you happen to hear that unmistakable repeating scratching noise from your hard drive then this is exactly your case. This led to a massive number of bad sectors, eventually killing the heads making all data inaccessible. After some time magnetic layer started to fall off the platters creating dust inside the HDA(Head Disk Assembly). It is believed their problems were mainly connected with glass platters - new technology introduced by Hitachi in these hard drives. The CMOS Drive does not recognized the Hard Drive. The PCB of the HTS548040M9AT00 seems like is burnt but no smoke coming out, the issue is that when you touch the PCB Boatd it seems hot and i can smell something when I smell it closely.
0 Comments
Leave a Reply. |
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |